1999 – 2004 Jeep WJ Grand Cherokee Technical Service Bulletins

00 Newest Bulletins

TSB # Date TSB Title 99 00 01 02 03 04  2400210 01/13/10  NEW HVAC SUB-ASSEMBLY COMPONENTS (supersedes 2400104 dated January 20, 2004) X X X X X X  2100908 03/05/08  FLASH: TRANSMISSION NOT SHIFTING OR IN DEFAULT OPERATION… (export fashions) X X X  2101407 10/16/07  AUTO TRANSMISSION FLUID USAGE ATF+4 (supersedes 2100404 dated 3/16/04) X X X X X X  2100307 02/09/07  AUTOMATIC TRANSMISSION DIAGNOSTIC TEAR DOWN PROCEDURE X X X X X X  2400906 12/18/06  WG DIESEL AUTOMATIC TEMPERATURE CONTROL (ATC) X X  2400606 08/09/06  A/C COOLING COIL ODOR (supersedes 2401305 dated August 4, 2005) X X X X X X  0500306 07/21/06  FRONT BRAKE INSPECTION PROCEDURE – CLASS ACTION LAWSUIT X X  0803006 07/12/06  POWERTRAIN CONTROL MODULE INITIALIZATION X X X X X X

02 Suspension

TSB # Date TSB Title 99 00 01 02 03 04  021099 07/30/99  TIE ROD AND DRAG LINK SLEEVE CLAMP BOLT TORQUE REVISION X  021299 08/20/99  FRONT END ALIGNMENT / BALL JOINTS (See # 0200102 dated 06/10/02) X X  021199a 12/31/99  IMPROVED TRACK BAR & UPPER CONTROL ARM TO REDUCE FRONT DRIVELINE NVH X  0200102 06/10/02  SPECIAL OFFSET BALL JOINT – ALLOWS ADJUST TO CASTER AND CAMBER ANGLES X X X  0200204 03/16/04  SUSPENSION SQUEAK / SQUAWK (outmoded by 0200204a dated 5/25/04) X X X X X X  0200204a 05/25/04  SUSPENSION SQUEAK / SQUAWK – FRONT STABILIZER BAR BUSHINGS X X X X X X

03 Differential / Driveline

TSB # Date TSB Title 99 00 01 02 03 04  030399 05/28/99  NOISY FRONT PROPELLER SHAFT REAR CONSTANT VELOCITY JOINT X  030599 09/24/99  AXLE DIAGNOSIS X X  030799 10/29/99  INTERMITTENT BUMP FELT AFTER VEHICLE HAS COME TO A FULL STOP (outmoded by 030400 dated 5/23/00) X X  030899 11/26/99  NEW 186FBI FRONT AXLE PINION GEAR FLANGED NUT & GROUND SPACER X X  030300 03/03/00  REAR AXLE WHINE 40 MPH+ X X  030400 05/23/00  INTERMITTENT BUMP FELT AFTER VEHICLE HAS COME TO A FULL STOP X X  030500 07/21/00  QUALITY IMPROVEMENTS TO ADDRESS FRONT AXLE WHINE AND 2,400 RPM MOAN X X  0300101a 07/14/01  FRONT AXLE WHINE (I6 / 4WD solely) X X X  0300302a 10/28/02  REAR AXLE WHINE SOUND X X X  0300203 08/29/03  FLUID WEEPAGE PAST REAR AXLE VENT LINE JIGGLE CAP X X X X X X

05 Brakes

TSB # Date TSB Title 99 00 01 02 03 04  050199 02/26/99  BRAKE SQUEAL PRESENT AT SPEEDS OVER 35 MPH X  050599 06/18/99  MATCH MOUNTING BRAKE ROTORS X  050299a 09/10/99  BRAKE ROUGHNESS OR PEDAL PULSATION (See # 0500302b) X  050100a 04/14/00  BRAKE ROUGHNESS OR PEDAL PULSATION (See # 0500302b) X X  0500501a 09/14/01  BRAKE ROUGHNESS OR PEDAL PULSATION (See # 0500302b) X X X X  0500302b 12/16/02  FRONT BRAKE PULSATION DURING LIGHT TO MODERATE BRAKE APPLICATION X X X X  0500306 07/21/06  FRONT BRAKE INSPECTION PROCEDURE – CLASS ACTION LAWSUIT X X

07 Cooling

TSB # Date TSB Title 99 00 01 02 03 04  0700201 03/02/01  ELEVATED ENGINE TEMP. DUE TO DELAYED START OF HYDRAULIC COOLING FAN X  0700502 12/16/02  NEW SOLENOID FOR DTC P1499 – HYDRAULIC FAN SOLENOID CIRCUIT FAULT X X X

08 Electrical

TSB # Date TSB Title 99 00 01 02 03 04  081698 04/17/98  RADIO TRANSMITTING EQUIPMENT (outmoded by 082399 dated 07/09/99) X  083698 07/24/98  USE OF TWO DIGIT CALENDAR YEAR CODES IN AUTOMOTIVE COMPUTERS X  084798 08/30/98  INTERMITTENT OPER. OF PWR DOOR LOCKS, RKE, PWR WINDOWS (outmoded by 080300 dated 02/11/00) X  080499 02/26/99  UNIVERSAL GARAGE DOOR OPENER RANGE X  080799 03/12/99  POWER DISTRIBUTION CENTER (PDC) SERVICE X  081499 05/21/99  VEHICLE START AND STALL OR VEHICLE NO-START X  081899 06/11/99  RADIO CLOCK DEFEAT X  082099 06/20/99  REVISED SUN ROOF EXPRESS OPEN POSITION X  082399 07/09/99  INSTALLATION OF RADIO TRANSMITTING EQUIPMENT X X  081299a 09/24/99  EVIC TEMPERATURE SENSOR DISPLAY X  083799 11/12/99  AIRBAG ON/OFF SWITCHES (outmoded by 0802501 dated 11/23/01) X X  083999 12/10/99  COMMUNICATIONS STOPPING BETWEEN JTEC PCM AND A GENERIC SCAN TOOL X  080300 02/11/00  POWER DOOR LOCKS, WINDOWS, KEYLESS ENTRY, MIRRORS – INTERMITTENT OPER. X  080600 02/25/00  WIRE SPLICE REPAIRS (outmoded by # 080600a dated 12/29/00) X X  080600a 12/29/00  WIRE SPLICE REPAIRS X X X  080800 03/17/00  KEYLESS ENTRY TRANSMITTER – INTERMITTENT OPERATION X X  081100 03/24/00  CD PLAYER – CD COMPATIBILITY X X  082200a 08/04/00  4.7L CAMSHAFT POSITION SENSOR CONTACTS TONE WHEEL X  082700 09/29/00  NON-DEPLOYED AIRBAG HANDLING PROCEDURES X X X  082800 09/29/00  SPEEDOMETER OR TACHOMETER INOPERATIVE X X  083300 11/03/00  CD – “COLD CD” FAULT CODE IN SALES CODE RBP/RAD/RBT AND RBY CD PLAYERS X  0803600 11/17/00  CIRCUITS AFFECTED BY IGNITION OFF DRAW FUSE X  0803800 12/08/00  SAFETY SYSTEMS – VEHICLE MODIFICATIONS / REPAIR X  0801001 05/25/01  AIRBAG / CLOCK SPRING SERVICE X X X  0801601 08/03/01  RADIO – CAUTION: LOCKING ANTENNA COLLAR X  0801701 09/21/01  SAFETY SYSTEMS – VEHICLE MODIFICATIONS / REPAIR X  0800401a 11/16/01  HEATED SEAT – INOPERATIVE (outmoded by # 0800401b dated 12/20/01) X X X  0802501 11/23/01  AIRBAG ON / OFF SWITCHES X X X  0800401b 12/20/01  HEATED SEAT – INOPERATIVE X X X  0800702 03/25/02  REMOTE KEYLESS ENTRY (RKE) PROGRAMMING PROCEDURES X X X X  0801402 09/02/02  LOUD AUDIBLE BURST OF STATIC OR DISTORTION FROM RADIO X  0801103 04/25/03  RKE KEY FOB ONLY OPERATES AT CLOSE RANGE ON DRIVER’S SIDE X  0801603 06/13/03  NEW AIRBAG CONTROL MODULE OPTIMIZED FOR CURRENT & PRIOR MODEL YR USE X X X  0802803 09/19/03  RADIO CD ERR MESSAGE X X X  0803003 10/24/03  NO AUX PWR TO TRAILER DUE TO MISSING TRAILER TOW HARNESS CIRCUIT BREAKER X  0800204 01/06/04  INTERMITTENT HORN CHIRP WHEN ATTEMPTING TO ENTER OR UNLOCK VEHICLE X X  0801404 03/30/04  RADIO INTERMITTENT AUDIO X  0801505 03/02/05  POWERTRAIN CONTROL MODULE INIT. (outmoded by 08-030-06 dated July 12, 2006) X X X X X X  0801605 03/03/05  TCM INTERNAL FAULT MAY CAUSE LOW LINE PRESSURE OR GEAR RATIO ERROR DTC X  0803006 07/12/06  POWERTRAIN CONTROL MODULE INITIALIZATION X X X X X X

09 Engine

TSB # Date TSB Title 99 00 01 02 03 04  090100a 09/11/00  ACCUMULATION OF FOAMY OIL EMULSION 4.7L ENGINE OIL FILL HOUSING X X  0900301 05/04/01  USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS X  0900303 08/01/03  4.0L MULTIPLE CYLINDER MISFIRE X X X X X X

14 Fuel

TSB # Date TSB Title 99 00 01 02 03 04  140798 12/11/98  FUEL FILLER CAP IS DIFFICULT TO REMOVE X  140199 02/19/99  SLOW FUEL FILL / REPEATED FUEL PUMP NOZZLE SHUT OFF X  140599 10/08/99  FUEL SYSTEM PRESSURE DIAGNOSTIC PROCEDURES X X  140600a 09/15/00  LONGER THAN NORMAL CRANK TIME… (outmoded by # 1400201 dated 03/16/01) X X  1400201 03/16/01  LONGER THAN NORMAL ENGINE CRANK TIME PRIOR TO ENGINE START X X X  1400601 10/12/01  PREMATURE FUELING NOZZLE SHUT-OFF WHEN FILLING TANK X  1400102a 10/07/02  FUEL CAP DIFFICULT TO REMOVE X

18 Performance

TSB # Date TSB Title 99 00 01 02 03 04  183198 09/25/98  OXYGEN SENSOR OPERATING DIFFERENCES X  183298 09/25/98  FLASH PROGRAMMING FAILURE RECOVERY (outmoded by # 1803705 dated 10/20/05) X  183598 12/18/98  ERRONEOUS MIL ILLUM. EVAPORATIVE PURGE SOLENOID CIRCUIT (P0443) X  183698 12/18/98  START AND STALL, IDLE UNDERSHOOT – LOST IAC STEPS X  183798 12/18/98  ADDITION OF A CLEAR FLOOD FEATURE X  184098 12/18/98  HIGH IDLE RPM ON DECELERATION W/ENGINE TEMPERATURE GREATER THAN 103 DEG. X  184198 12/18/98  IDLE RPM UNDERSHOOT/OVERSHOOT WHILE IN LOW RANGE 4WD X  184298 12/18/98  LONG CRANK TIMES WITH ENGINE TEMPERATURES BETWEEN 46-140 DEGREES F X  184398 12/18/98  ENGINE SAG WHEN THE A/C COMPRESSOR CYCLES X  184498 12/18/98  COLD ENGINE START OR PARTIAL COOL DOWN RESTARTING SAG/HESITATION X  184598 12/18/98  ENGINE VIBRATION, “BEAT” LIKE SOUND, OR “DRONE” X  184698 12/18/98  ENGINE IDLE UNDERSHOOT / DRIVEWAY DIE OUT WHEN SHIFTING TRANSMISSION X  180799 04/30/99  ERRONEOUS MIL ILLUM. (P1763) GOV. PRESS. SENSOR VOLTS (outmoded by # 210400 dated 6/30/00) X  180999 05/21/99  DIAGNOSTIC TROUBLE CODES CAUSED BY OPEN FUSE X  181299 06/18/99  DRBIII LEAK DETECTION PUMP MONITOR TEST X  181399 06/18/99  EXHIBITING AN ENGINE NO-START CONDITION X  181499 06/18/99  DRONE NOISE DURING WARM ENGINE IDLING X  181599 06/18/99  CHANGE TO OXYGEN SENSOR BIASING / SWITCHING AT IDLE WITH N OR P SELECTED X  181699 06/25/99  START-UP IMPROVEMENTS TO COMPENSATE FOR SEASONAL CHGES TO FUEL QUALITY X  181799 06/25/99  IMPROVED IDLE CONTROL DURING MOMENTARY ENGINE LOADING CONDITIONS X  182599 11/15/99  ENGINE MISFIRE PCM ERROR USING DRBIII X  180100 02/04/00  MISDIAGNOSED LEAK DETECTION PUMP SYSTEMS (P1494, P0442, P0455, P0456) X X  1800101 01/26/01  4.7L ENGINE PERFORMANCE ENHANCEMENTS X X  1800901 03/30/01  LEAK DETECTION PUMP OPERATION AND DIAGNOSIS X  1801001 04/20/01  ROUGH IDLE AT COLD TEMPERATURE (4.0L) X  1801201 05/25/01  GENERIC SCAN TOOL (GST) X X X X  1801301 06/11/01  ROUGH IDLE AT COLD TEMPERATURES (4.0L) X  1802101a 09/17/01  4.7L ENGINE PERFORMANCE ENHANCEMENTS X  1802501 10/15/01  45RFE AND 545RFE SHIFT QUALITY ENHANCEMENTS FOR THE 2-3, 4-5, AND 5-4 SHIFTS X X X  1801202 02/25/02  FLASH: COLD START RPM FLARE X X  1800502a 05/06/02  VEHICLE PERFORMANCE ENHANCEMENTS X  1802702 09/06/02  ROUGH IDLE AFTER RESTART… (outmoded by # 1803103 dated 09/05/03) X X X X  1801602a 09/23/02  FLASH: MIL ILLUM. FOR ERRONEOUS DTC P0456 – EVAP MON. SMALL LEAK DETECTED X  1800203 01/31/03  FLASH: MIL ILLUM. FOR ERRONEOUS DTC P0456 – EVAP MON. SMALL LEAK DETECTED X X  1800503b 07/04/03  FLASH: TRANSMISSION SHIFT… (outmoded by # 1801304 dated 03/30/04) X  1800503c 08/01/03  FLASH: TRANSMISSION SHIFT… (outmoded by # 1801304 dated 03/30/04) X  1803103 09/05/03  4.0L ROUGH ENGINE IDLE AFTER RESTART FOLLOWING A HOT SOAK X X X X X X  1803203 09/12/03  ERRONEOUS DTC’S RELATING TO 4.0L OXYGEN SENSOR HEATER FAILURE X  1800804 02/24/04  FLASH: LOW IDLE SPEED INDUCED DRONE AND/OR INTERMITTENT P/T T-CASE LAMP X  1801304 03/30/04  FLASH: TRANSMISSION SHIFT/SPEED CONTROL IMPROVEMENTS (supersedes 1800503c) X  1801904 04/27/04  FLASH: 4.7L HIGH OUTPUT – COLD ENGINE ROUGH IDLE OR HESITATION X  1802804 06/30/04  FLASH: 4.0L TORQUE CONVERTER LOCK-UP FEATURE X  1804504 12/18/04  FLASH: 4.7L WARM ENGINE ROUGH IDLE X X X  1803705 10/20/05  FLASH PROGRAMMING FAILURE RECOVERY USING DRBIII® X X X X X X

19 Steering

TSB # Date TSB Title 99 00 01 02 03 04  190600 09/15/00  STEERING GEAR HONK ON TURNS X X  1900301a 08/24/01  HONK-LIKE SOUND WHEN PERFORMING RIGHT TURNS AT LOW SPEED X X X  1900701 10/26/01  POWER STEERING FLUID USAGE (outmoded by # 1900503 dated 08/29/03) X X X X  1900901 10/26/01  DRIVER AIRBAG – TRIM COVER SERVICE X X X X  1900801 11/23/01  POP / TICK SOUND IN STEERING WHEEL AREA (outmoded by # 1900303 dated 08/29/03) X X X X  1900502 05/20/02  STEERING HONK ON 4.0L AND 4.7L VEHICLES X X X X  1900103 02/07/03  POP/TICK SOUND IN STEERING WHEEL AREA (outmoded by 1900504a dated 10/25/04) X X  1900203 02/28/03  POWER STEERING MOAN OR WHINE-LIKE SOUND WHEN TURNING X X  1900303 08/29/03  POP / TICK SOUND IN STEERING WHEEL AREA (automobiles constructed on or earlier than 1/13/02) X X X X  1900503 08/29/03  POWER STEERING FLUID USAGE X X X X X X  1900504a 10/25/04  POP / TICK SOUND IN STEERING COLUMN (supersedes 1900504 dated 05/25/04) X X X

21 Transmission

TSB # Date TSB Title 99 00 01 02 03 04  211398 10/16/98  FLUID LEVEL INSPECTION PROCEDURE… (outmoded by 211199 dated 07/23/99) X  211498 12/04/98  QUICK LEARN CLUTCH VOLUME PROCEDURES ON 45RFE TRANSMISSIONS X  211698 12/04/98  REVISED FRONT BAND ADJUSTMENT FOR 42RE TRANSMISSIONS X  211198 12/11/98  NEW TRANSMISSION DIAGNOSTIC SIMULATOR TOOL X  211798 12/11/98  NV 247 TRANSFER CASE SHUDDER (outmoded by # 210299 dated 02/12/99) X  210299 02/12/99  SHIFT QUALITY IMPROVEMENTS X  210899 04/30/99  BUZZ, WHINING OR MOANING LIKE NOISE FROM COLD TRANSMISSION (REVERSE GEAR) X  211199 07/23/99  TRANSMISSION FLUID LEVEL INSPECTION PROCEDURE/SERVICE CAUTIONS X X  210199a 08/13/99  NV247 LOW SPEED GRINDING NOISE TRANSFER CASE X  210999 06/04/99  NV247 SHUDDER NOISE IN TRANSFER CASE X  211399 09/03/99  DRIVE LEARN PROCEDURES FOR 45RFE TRANSMISSIONS X X  212299 12/03/99  NV-242 AND NV-242HD SECTOR SHAFT SEAL OIL SEEPAGE (outmoded by # 210300 dated 3/10/00) X  210100 02/04/00  NV-242 & NV-242HD TRANSFER CASE OIL SEEPAGE FROM SECTOR SHAFT OIL SEAL X X  210300 03/10/00  RED-IN-COLOR OIL SEEPAGE FROM UNDER THE VEHICLE X  210400 06/30/00  ERRONEOUS MIL ILLUMINATION FOR P1763 – TRANS. GOV. PRES. SENSOR VOLTS TOO HIGH X  210900 09/15/00  45RFE TRANS. QUALITY ENHANCEMENTS… (outmoded by # 1802501 dated 10/15/01) X  2100601 06/29/01  AUTO TRANSMISSION FLUID USAGE ATF+4 (outmoded by 2100404 dated 3/16/04) X X X X  2101101 09/12/01  NV247 TRANSFER CASE SEEPAGE X X  2100202 07/08/02  REVISION IN DIAG. PROCEDURES AND LABOR TIME FOR RE TRANSMISSIONS X X X X X  2100404 03/16/04  AUTO TRANSMISSION FLUID USAGE ATF+4 (outmoded by # 2101407 dated 10/16/07) X X X X X X  2100307 02/09/07  AUTOMATIC TRANSMISSION DIAGNOSTIC TEAR DOWN PROCEDURE X X X X X X  2101407 10/16/07  AUTO TRANSMISSION FLUID USAGE ATF+4 (supersedes 2100404 dated 3/16/04) X X X X X X  2100908 03/05/08  FLASH: TRANSMISSION NOT SHIFTING OR IN DEFAULT OPERATION… (export fashions) X X X

22 Wheels

TSB # Date TSB Title 99 00 01 02 03 04  2200101 02/23/01  CHROME WHEEL CARE (outmoded by 2200403 dated 09/26/03) X  2200101a 09/28/01  CHROME WHEEL CARE (outmoded by 2200403 dated 09/26/03) X X  2200102 03/11/02  CHROME WHEEL CARE (outmoded by 2200403 dated 09/26/03) X X X  2200403 09/26/03  CHROME WHEEL CARE X X X X  2200103 02/07/03  TIRE PRESSURE SYSTEM PERFORMANCE AFFECTED WITH TEMP CHANGES X X X

23 Body

TSB # Date TSB Title 99 00 01 02 03 04  234598 10/09/98  IN TRANSIT PROTECTIVE FILM X  236098 12/11/98  SUNSHADE FABRIC DELAMINATES FROM SUBSTRATE ALONG EDGES X  236198 12/18/98  WATER LEAK AT THE REAR LIFT GATE FLIPPER WINDOW X  231599 03/21/99  FRONT POWER WINDOW TILTS OR TIPS FORWARD IN THE OPENING WHEN RAISED X  231499 05/21/99  DOOR WEATHER SEAL RETENTION X  231799 05/21/99  ROOF RACK CROSS BAR SHIPPING LOCATION X  233599a 10/01/99  CHILD SEAT TETHER ANCHORS X X  233899 10/01/99  ROOF JOINT MOLDING DISTORTION X  234499 11/05/99  WATER LEAK AT THE REAR OF THE SUNROOF X X  230800 03/03/00  CHILD SEAT TETHER ANCHORS (outmoded by # 230800b dated 11/24/00) X X  231000 03/03/00  WINDOW REGULATOR – STICKING AT TOP OF TRAVEL X X  231700 05/05/00  CARGO COVER SHADE BRACKET BREAKS X X  232100 05/19/00  FRONT SEAT BINDS OR STICKS (MANUAL SEATS) X  230800a 07/07/00  CHILD SEAT TETHER ANCHORS (outmoded by # 230800b dated 11/24/00) X X  233000 08/04/00  FRONT SEAT BELTS SLOW TO RETRACT X X  2303800 10/13/00  SEAT BELT TURNING LOOP COVER REPAIR X X  234100 11/01/00  OPTIMUM ROOF RACK POSITION (see # 2301303 dated 05/30/03) X X X  230800b 11/24/00  CHILD SEAT TETHER ANCHORS X X  2300301 02/02/01  HEAD IMPACT UPPER INTERIOR FEDERAL MOTOR VEHICLE SAFETY STANDARDS X  2302701 09/21/01  OUTSIDE REARVIEW MIRROR GLASS… (outmoded by # 2301502 dated 04/01/02) X X X X  2301502 04/01/02  OUTSIDE REARVIEW MIRROR GLASS REPLACEMENT X X X X  2301902 05/20/02  CLOTH COVERS ON BOTH FRONT SEAT CUSHIONS MAY LOOSEN AND WRINKLE X  2302002 05/20/02  NEW REPAIR PROCEDURES W/ SEPARATE LIFTGATE LATCH MOTOR AND COMPONENTS X X X X  2303302 07/22/02  REAL WOOD TRIM SCRATCH REPAIR (outmoded by 2301204 dated 04/27/04) X X X  2303402 07/22/02  OPTIMUM ROOF RACK CROSS BAR POSITION (outmoded by 2301303 dated 5/30/03) X X  2304302 09/30/02  SUNSHADE MAY PARTIALLY CLOSE DURING HARD APPLICATION OF THE BRAKES X  2300903 04/18/03  REAL WOOD TRIM SCRATCH REPAIR (outmoded by 2301204 dated 04/27/04) X X  2301303 05/30/03  OPTIMUM ROOF RACK CROSS BAR POSITION (supersedes 2303402 dated July 22, 2002) X X X  2301503 06/06/03  WIND-LIKE SOUND AT TOP REAR CORNER OF FRONT DOOR X X X X X X  2302603 10/24/03  NEW SNAP-IN RETAINER TO IMPROVE RETENTION OF MOPAR AIR DEFLECTOR TO HOOD X X X X X X  2300904 03/09/04  POPPING OR CLICKING-LIKE SOUND IN AREA OF FRONT SEAT FRAME X X X X X X  2301204 04/27/04  REAL WOOD TRIM SCRATCH REPAIR (supersedes 2300903 dated 04/18/03) X X X  2302704 07/19/04  FLUTTER-LIKE SOUND FROM OUTSIDE MIRROR AT HIGH VEHICLE SPEEDS (export fashions) X X X X X X

24 Heating & AC

TSB # Date TSB Title 99 00 01 02 03 04  240199 01/29/99  A/C REFRIGERANT CHARGE X  240299 01/29/99  A/C COMPRESSOR SERVICE PRECAUTIONS X  240799 04/30/99  REDUCED AIRFLOW FROM CENTER OUTLETS X  240899 05/14/99  WHISTLING SOUND FROM HEATER BLOWER X  241699 08/20/99  AZC CONTROL MODULE RECALIBRATION X  242499 11/12/99  HEATER A/C SYSTEM CHANGING TO DEFROST MODE WHEN ACCELERATING X X  242599 11/12/99  COLD AIR LEAKING INTO PASSENGER COMPARTMENT FOOT WELL X X  240699a 12/14/99  CONDENSATION ON EXTERIOR OF HEATER HOUSING X X  240100 02/04/00  IMPROVED DRIVERS SIDE FLOOR DUCT X X  2400701 05/18/01  CHANGE IN OUTLET TEMPERATURE FROM DESIRED SETTING X X X  2400902 10/08/02  AC SYSTEM LEAK DETECTION X X X X X  2400303 05/23/03  A/C SYSTEM ADDITIVES X X X X X X  2400104 01/20/04  NEW HVAC SUB-ASSEMBLY COMPONENTS (outmoded by 2400210 dated January 13, 2010) X X X X X X  rr-04-008 04/14/04  VACUUM HOSE ELBOW MAY RESTRICT VACUUM TO HVAC OR CRUISE SYSTEMS X  2401305 08/04/05  A/C COOLING COIL ODOR (outmoded by 2400606 dated August 9, 2006) X X X X X X  2400606 08/04/05  A/C COOLING COIL ODOR (supersedes 2401305 dated August 4, 2005) X X X X X X  2400906 12/18/06  WG DIESEL AUTOMATIC TEMPERATURE CONTROL (ATC) X X  2400210 01/13/10  NEW HVAC SUB-ASSEMBLY COMPONENTS (supersedes 2400104 dated January 20, 2004) X X X X X X

25 Emissions

TSB # Date TSB Title 99 00 01 02 03 04  250298 10/23/98  INSPECTION MAINTENANCE TESTING – OBD II “CARB” READINESS X  250299 11/29/99  CATALYST MONITOR DOES NOT ILLUMINATE MIL OR SET FAULT CODE X  2500101 02/02/01  GENERIC SCAN TOOL MAY NOT DISPLAY CERTAIN DTC’S & ERRONEOUS LDP SW FAULT X  2500401 05/11/01  ADDITIONAL DIAGNOSTICS FOR DTC’S CAUSED BY AN EVAPORATIVE SYSTEM LEAK X X X  2500102 02/11/02  MIL ILLUMINATION LDP (outmoded by # 2500102a dated 09/02/02) X  2500102a 09/02/02  MIL ILLUM., DTC P0442, P0455, OR P0456 – LEAK DETECTION PUMP, LEAK DETECTED X  2500103 02/21/03  DUTY CYCLE PURGE SOLENOID CAUSES TICKING-LIKE SOUND FROM ENGINE BAY X X X  2500104 10/25/04  EVAPORATIVE SYSTEMS SERVICE (Information solely) X X X X X X